Power Systems Talk about motors, ESC speed controllers, gear drives, propellers, power system simulators and all power system related topics

ESC question

Old 01-15-2022, 08:40 PM
  #1  
Photon Phil
New Member
Thread Starter
 
Join Date: Sep 2013
Posts: 12
Default ESC question

I bought an AVIAN 60 amp esc. I installed it in my airframe and it works, BUT on full throttle and just below full it hunts. It speeds up then slows down just a little. You can easily hear it doing this.
Any thoughts on why it does this? This is my first so called smart esc. It seems that it is smarter than I am. TIA
Photon Phil is offline  
Old 01-16-2022, 05:51 PM
  #2  
Wildflyer
Past President of PSSF
 
Wildflyer's Avatar
 
Join Date: Sep 2009
Location: Lacey WA, 1 mile E of Mushroom Corner
Posts: 2,224
Default

It may be warning you that the battery voltage is low.

I have an ESC that goes into pulse mode (my name) when the voltage drops, I like that better than just stopping the motor and then you have to drop to low throttle to get a little burst for landing control then it might shut off again when you need it. (Sometimes I forget the time to land)

Check your running battery voltage with a wattmeter or hook up a voltmeter so you can read it while giving your plane full power.
Tie the plane down so you don't have to think about it getting away. Seen that happen.
Wildflyer is offline  
Old 01-16-2022, 06:42 PM
  #3  
Photon Phil
New Member
Thread Starter
 
Join Date: Sep 2013
Posts: 12
Default

Thanks Wildflyer I'll give it a try.
Photon Phil is offline  
Old 01-16-2022, 08:12 PM
  #4  
Fishbonez
Love my Stinger
 
Fishbonez's Avatar
 
Join Date: Apr 2011
Location: Wyoming
Posts: 2,956
Default

Are there any tones when this begins to happen?
Attached Files
File Type: pdf
Avian-Manual-EN.pdf (662.7 KB, 5 views)
Fishbonez is offline  
Old 01-16-2022, 08:58 PM
  #5  
solentlife
Super Contributor
 
solentlife's Avatar
 
Join Date: Oct 2010
Location: Ex UK Brit now in Latvia west coast - Ventspils
Posts: 12,856
Default

I have had this happen on a couple of models but for different reasons each.

Model 1. Battery was nearing LVC (Low Voltage Cutoff) and it went into pulsing mode - you could hear it while flying as the motor varied speed. It gave me just enough warning to get model down.

Model 2 : The ESC was only just enough for the power demand and as it hit max - it started to pulse the power to motor, avoiding burn out. It also got hot which was what guided ,me to solution - bigger ESC !!

So first question : Was LiPO charged when you tested the setup ? If not maybe 1. is the answer ?

Second question : have you Wattmetered the setup to see that you have adequate spare rating on the ESC ?

Third question : Is the ESC Motor Timing correct for the motor ? Some of these 'smart' ESC's are too smart and can be a pain to get right. It may be a possibility to try other Timing settings ??

I would suggest a Wattmeter test as well.
solentlife is offline  
Old 01-16-2022, 08:58 PM
  #6  
ron_van_sommeren
homo ludens modelisticus
 
ron_van_sommeren's Avatar
 
Join Date: Jul 2005
Location: near Nijmegen, Nederland
Posts: 1,399
Default

Don't forget to measure current as well.
ron_van_sommeren is offline  
Old 01-17-2022, 10:47 AM
  #7  
solentlife
Super Contributor
 
solentlife's Avatar
 
Join Date: Oct 2010
Location: Ex UK Brit now in Latvia west coast - Ventspils
Posts: 12,856
Default

With the Wattmeter test - we would be looking for :

1. Amp draw and its increase as we open throttle ... to see point at which it starts the problem
2. Displayed Volts and its 'sag' as the throttle is advanced ... till point problem starts.
3. Watts displayed and its increase as throttle is advanced etc.

With result of #1 : you get to really see if ESC you have is suitable or not. It is usual to have at least 30% margin of ESC rating above max amp draw of motor.
#2 - divide by number of cells and this gives average of cell voltage at that problem point ... it may show a figure close to LVC ... indicating a poor battery or too high a LVC.
#3 - gives a check on Amps / Voltage as this is a mathematical value.
solentlife is offline  
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
AEAJR
General Electric Discussions
276
11-14-2021 05:11 PM
AEAJR
Beginners
166
11-02-2021 01:03 PM
CHELLIE
Hi-Performance and Sailplanes
2015
05-28-2020 09:50 PM
Flysfloats
General Electric Discussions
8
10-27-2019 09:42 AM
boeing_737
General Electric Discussions
34
08-23-2011 02:59 PM

Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is On


Quick Reply: ESC question


Contact Us - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service - Do Not Sell My Personal Information -

Copyright 2021 MH Sub I, LLC dba Internet Brands. All rights reserved. Use of this site indicates your consent to the Terms of Use.

Page generated in 0.08370 seconds with 15 queries